2011 Dodge Grand Caravan Fuel Pump Relay Kit Instructions

September 29, 2021

History shows that a defective TIPM fuel pump relay will start off as an occasional no start scenario typically when the vehicle is cold and then get worse over the next 2-3 weeks. Download a PDF copy of the 2011 Dodge DurangoJeep Grand Cherokee Safety Recall P54NHTSA 14V-530 Fuel Pump Relay instructions.

Repair Kit For 07 08 09 10 11 Dodge Magnum Nitro Tipm Fuse Box Fuel Pump Relay Ebay

This connection feeds 12 VDC to your TIPM via.

2011 dodge grand caravan fuel pump relay kit instructions. Our 2011 van went to the dealer with the above symptoms and they said bad fuel pump. In this video we will show you how to fix the 2011 Dodge caravan no start issue caused buy the tipm fuel pump relay. 2011 Power Outlet Fuses Number Cavity Ampere rating A Description 1 M7 20 Power Outlet Center Seat Opt or with Console Rear 2 M6 20 Cigar Lighter Instrument Panel or with Console Front 3 M36 20 Power Outlet Instrument Panel or with Console Center Totally.

Our TIPM BypassTest Cables work perfectly on these vehicles as long as you have not allowed your dealer to install an external fuel pump relay ie. The recall is for the Durango and Ram but this shows that it is much the same on the Grand CaravanUpda. To check if you have an external relay locate your fuse box TIPM under the hood of your vehicle.

5 - Add External Fuel Pump Relay Normally 50 if you solder yourself This solution is similar to Star case S and the official Dodge DurangoJeep Grand Cherokee recall where youll need to purchase an external fuel pump relay. Not the perfect video but it will help you to find some answers on your own lets you know if you have a bad or good fuel pump or fuel pump relay. TIPM Fuel Pump Relay BypassTest Cable KitMost 2007-2016 DodgeChryslerJeepVW.

2011-2012 Dodge RAM 2500 Gas OEM Rebuilt TIPM Fuse Box 04692319. Install External Fuel Pump Relay 1. Did it second time and car started and stayed running.

External relay installations involve the cutting and splicing of TIPM harness wires which completely disconnects your normal fuel pump. Position the passenger seat fully forward. Working at the TIPM module in the engine compartment remove the fuel pump fuse.

My 2011 Durango a neighbors 2012 Durango and another neighbors 2012 Grand Cherokee all have TIPM issues. Note that your vehicle may not work with this modification due to a lack of information from vehicle manufacturers. Open hood and remove 20A fuel pump fuse M25.

Install the fuel pump fuse into a fuse breakout loop. Then install the test loop into the fuel pump fuse location. Remove the existing 20A fuse in fuse slot M7.

Put probe on the M25 fuse and it was flickering lightlyone flicker every 10-15 seconds. Open the battery access cover located under the passenger front seat and disconnect the negative battery cable Figure 2. Insert one end of your testbypass cable into the M25 fuse slot of your fuse box with orientation per the image below if using a Standard Cable with LED.

The part used to fix the fuel pump relay problem for the nationwide recall on 2011-2013 Dodge Durango and Jeep Grand Cherokees. Discussion Starter 1 May 18 2017. Ecu wiring diagram dodge ram Dodge Ram.

--- Click Here to view. For vehicles that wont start out of gas or have a dead battery fuel pump runs after turning vehicle off. Mine was the first to go.

Open the black plastic lid and locate a large hex hut in the upper left corner that is your positive battery connection. Used started fluid in TB and car started and died. External relay installations involve the cutting and splicing of TIPM harness wires which completely disconnects your normal fuel pump.

Shows the Dodge recall repair on the Grand Caravan. Here is a pinout of the relay so you can tell which pins are 30 and 87. Also if you find your battery is dead the next morning you may have a bad TIPM.

Our TIPM BypassTest Cables work perfectly on these vehicles as long as you have not allowed your dealer to install an external fuel pump relay ie. I know this seems to only plague the 2011s but if your van that spins over but wont start or fires and then dies. Fuse M25 20 AMP located in the TIPM.

Verify that M25 is your fuel pump slot. Star case S1308000399 instructions for installing an external relay. On the external fuel pump relay go ahead and disconnect the relay and hook a jumper wire between cavity 30 and 87 of the relay connector and check for power at the fuel pump connector.

2011 Dodge Grand Caravan No start suspected fuel pump relay. Dodge Grand Caravan 2011 fuse box diagram Year of production. Remove and save the Totally Integrated Power Module TIPM access cover.

The part used to fix the fuel pump relay problem for the nationwide recall on 2011-2013 Dodge Durango and Jeep Grand Cherokees. We are unsure if all TIPM wiring is the same for the TIPM-7 series. Starting problems related to a faulty fuel pump relay typically occur in the morning when the vehicle is cold and progressively get worse over a period of weeks or months.

Sep 28 Test TEMPORARILY bypass fuel pump relay. Safety Recall P54 Fuel Pump Relay Page 4 B. Solutions to TIPM fuel pump relay and other problems on 2007-2016 Chrysler Dodge Jeep and VW vehicles Ram Caravan Town Country Routan Durango Grand Cherokee etc.

Three Tipm Fuel Pump Relay Repair Options For 2011 Durango Jgc Dodge Durango Forum